University of Limerick
Cusack_2019_Evaluation.pdf (631.13 kB)

An evaluation of the general composition and critical raw material content of bauxite residue in a storage area over a twelve-year period

Download (631.13 kB)
journal contribution
posted on 2023-01-11, 14:09 authored by Patricia B. Cusack, RONAN COURTNEYRONAN COURTNEY, Mark G. Healy, Lisa M.T. O'Donoghue, Éva Ujaczki
Bauxite residue, the by-product produced in the alumina industry, is being produced at an estimated global rate of approximately 150 million tonnes per annum. Currently, the reuse of bauxite residue is low (∼2%), due to limitations associated with its alkalinity, salinity, low solid content, fine particle size and potential leaching of metal(loid)s. It has been identified as a potential secondary source for critical raw materials such as vanadium, gallium and scandium, which currently have an associated supply risk and high economic cost within Europe. However, there is an uncertainty regarding the possible variation in these and other physico-chemical, elemental and mineralogical parameters within bauxite residue disposal areas. This paper aimed to address this knowledge gap by examining the variation of these parameters in a bauxite residue disposal area (BRDA) over a twelve-year period. The general composition did not vary greatly within the bauxite residue examined, with the exception of pH and electrical conductivity, which ranged from 10 ± 0.1 to 12.0 ± 0.02 and from 0.4 ± 0.01 to 3.3 ± 0.2 mS cm−1, respectively. The bauxite residue contained critical raw materials, of which the amount of vanadium, gallium and scandium did not vary significantly over time. The vanadium and gallium were present in larger amounts compared to other European bauxite residues. On average the vanadium, gallium and scandium content measured in the bauxite residue samples were 510 ± 77.8, 107 ± 7.3 and 51.4 ± 5.4 mg kg−1, respectively. This shows promise for the potential reuse of bauxite residue as a secondary source for critical raw materials and also indicates that BRDAs may be potential mines for critical raw material extraction.



Journal of Cleaner Production;208, pp. 393-401




peer-reviewed The full text of this article will not be available in ULIR until the embargo expires on the 9/10/2020

Other Funding information



This is the author’s version of a work that was accepted for publication in Journal of Cleaner Production. Changes resulting from the publishing process, such as peer review, editing, corrections, structural formatting, and other quality control mechanisms may not be reflected in this document. Changes may have been made to this work since it was submitted for publication. A definitive version was subsequently published in Journal of Cleaner Production, 2019, 208, pp. 393-401,



Also affiliated with

  • Bernal Institute

Department or School

  • Biological Sciences
  • School of Engineering

Usage metrics

    University of Limerick


    No categories selected


    Ref. manager